Front Door Window Glass Wont Roll Up or Out of Channel (Replace Guide) #01-08-64-018A [Archive] - GrandAmGT.com Forum

PDA

View Full Version : Front Door Window Glass Wont Roll Up or Out of Channel (Replace Guide) #01-08-64-018A


iceman
08-26-2002, 08:34 AM
Front Door Window Glass Won't Roll Up or Out of Channel (Replace Guide)
1999-2002 Oldsmobile Alero

1999-2002 Pontiac Grand Am

This bulletin is being revised to change the warranty information. Please discard Corporate Bulletin # 01-08-64-018 (Section 08--Body and Accessories).

Condition
Some customers may comment that the front door window glass won't roll up or is out of the channel.

Cause
The front window run channel guide(s) may have broken, or the guide(s) may have broken and damaged the sash channel on the bottom of the door glass.

Correction
Remove the front window regulator. Refer to the Doors subsection in the Body and Accessories section of the Service Manual.
Remove the door glass from the door.
Inspect the plastic sash channel on the bottom of the glass. If the sash channel has come off the glass, refer to Corporate Bulletin Number 01-08-64-012A for repair.
Inspect the regulator for damage.




Important
When removing the cable from the guide, take care not to damage (kink, cut or fray) the cable.


If the regulator is OK, remove the cable from the guide as shown.



Rotate the guide to remove it from the run channel.
Install the new guide in the same manner as it was removed.
Install the cable into the guide.
Install the window regulator. Refer to the Doors subsection in the Body and Accessories section of the Service Manual.
Verify the window operation.